check off sheets/powe points

Question 0

HOW MANY RPM’S ARE PRODUCED WHEN ENGINE IS IN HIGH IDLE?

IDLING SHUT DOWN TIPS DOC.

Answer 0

1100 RPM’S

Question 1

WHAT DOES IDLING PRODUCE?

IDLING SHUT DOWN TIPS DOC.

Answer 1

SULFURIC ACID.

BREAKS DOWN: ENGINE OIL, EATS INTO BEARINGS,RINGS AND VALVES STEMS, ENGINESURFACES.

Question 2

WHAT TYPE OF ALTERNATOR IS ON ALL DEPT. ENGINE AND LADDERS?

IDLING AND SHUT DOWN TIPS DOC.

Answer 2

400 AMP ALTERNATOR

Question 3

HOW MANY AMPS ARE PRODUCED WHEN APPARATUS IS AT IDLE?

IDLING AND SHUT DOWN TIPS DOC.

Answer 3

200-230 AMPS

Question 4

HOW MANY AMPS ARE PRODUCED WHEN APPARATUS IS AT HIGH IDLE (1100 RPM’S)?

IDLING AND SHUT DOWN TIPS DOC.

Answer 4

400 AMPS

Question 5

WHAT IS THE PROPER VOLTMETER READING DURING NORMAL OPERATING CONDITIONS?

IDLING AND SHUT DOWN TIPS DOC.

Answer 5

13.5-14.8

Question 6

BATTERY VOLTAGE IS 12.8 WHAT IS HAPPENING IF VOLTMETER IS READING LOWER THAN 12.8?

IDLING AND SHUT DOWN TIPS DOC.

Answer 6

APPARATUS IS IN A NO CHARGE STATE.

Question 7

ALLOWING THE ENGINE TO RUN AT IDLE FOR 2-4 MINUTES DOES WHAT?

IDLING AND SHUT DOWN TIPS DOC.

Answer 7

ALLOWS ENGINE TO COOL AND PERMITS TURBO CHARGER TO SLOW DOWN.

Question 8

IDLING AND SHUT DOWN PROCEDURES DEPENDS ON WHAT?

IDLING AND SHUT DOWN TIPS DOC.

Answer 8

WEATHER CONDITIONS (HOT/COLD), EMERGENCY STATUS/NONEMERGENCY STATUS, NOT IN USE.

Question 9

ANYTIME THE ARIEL APPARATUS IS BEYOND WHAT DEGREE FROM LEVEL WILL YOU RECEIVE A WARNING ON THE CZIC?

Answer 9

8 DEGREES

Question 10

CAN YOU USE ARIEL APPARATUS ON A UPHILL OR DOWN HILL SLOPE?

ARIEL LEVELING

Answer 10

YES PREFERABLY UPHILL

TRUCK MUST BE CAPABLE OF BEING LEVEL

Question 11

WHAT MUST BE USED WITH OUTRIGGERS?

ARIEL LEVELING

Answer 11

OUTRIGGER PADS AND SAFETY PINS

Question 12

WHAT IS THE ARIEL LEVELING METHOD?

ARIEL LEVELING

Answer 12

AREA AROUND MUST BE CLEAR FOR OUTRIGGER EXTENSION
OUTRIGGER STABILIZER PADS WILL BE USED
SAFETY PINS FOR OUTRIGGERS WILL BE USED
FRONT AXLE BRAKE LOCK VALVE SHALL BE SET
USE WHEEL CHOCKS WHEN POSSIBLE

Question 13

WHY SHOULD SOME TIRES BE LEFT ON GROUND WHEN LEVELING ARIEL APPARATUS?

ARIEL LEVELING

Answer 13

GIVES ADDED RESISTANCE TO SLIDING

Question 14

WHEN TRYING TO REACH OVER THE FRONT OF ARIEL APPARATUS WHERE MUST FRONT TIRES BE?

ARIEL LEVELING

Answer 14

IN FIRM CONTACT WITH THE GROUND.

Question 15

CAN YOU MOVE OUTRIGGERS WITH ARIEL OUT OF BED?

ARIEL LEVELING

Answer 15

NO /NEVER

Question 16

WHEN SHOULD YOU DRAIN THE AIR BRAKE AND STEP AIR SUPPLY TANK?

AIR TANKS

Answer 16

EVERY SATURDAY

Question 17

WHAT DOES THE AIR SYSTEM COMPRISE OF?

Answer 17

AIR COMPRESSOR
AIR DRYER
AIR TANKS
AIR OPERATED SYSTEM (I.E) BRAKES, STEPS

Question 18

WHAT DOES THE AIR DRYER DO?

Answer 18

REMOVES CONDENSATION AND OIL HOWEVER SOME STILL GETS THROUGH.

AIR DRYERS ARE REBUILT AT RESOURCE YEARLY.

Question 19

WHAT IS THE FIRST TANK IN THE AIR SYSTEM CALLED?

Answer 19

WET TANK, MOST OIL/CONDENSATION IS ACCUMULATED IN THIS TANK

Question 20

TYPICALLY HOW MANY CHASSIS AIR SUPPLY TANKS ARE THERE?

Answer 20

4